2011-08-08_REVISION - M1977493 ‎(35)‎

• Permit No: M1977493
• IBM Index Class Name: REVISION
• Doc Date: 8/8/2011
• Doc Name: EPP- Material Safety Data
• From: Climax Molybdenum
• To: DRMS
• Type & Sequence: TR18
• Media Type: D
• Archive: No

•
•
High Calcium QuickLime.txt
UP TO 25 MG /M3:
(APF = 25):
ANY SUPPLIED -AIR RESPIRATOR OPERATED IN A CONTINUOUS -FLOW MODE. ANY POWERED,
AIR PURIFYING RESPIRATOR WITH A HIGH - EFFICIENCY PARTICULATE FILTER.
FOR RESPIRABLE QUARTZ LEVELS THAT EXCEED OR ARE LIKELY TO EXCEED AN 8 -HR TWA
OF 0.1 MG /M3, A NIOSH APPROVED (N /R /P95) DUST RESPIRATOR IS RECOMMENDED.
FOR RESPIRABLE QUARTZ LEVELS THAT EXCEED OR ARE LIKELY TO EXCEED AN 8 -HR TWA
OF 0.5 MG /M3. A NIOSH APPROVED HEPA (N /R /P100) FILTER RESPIRATOR IS
RECOMMENDED.
FOR RESPIRABLE QUARTZ LEVELS THAT EXCEED OR ARE LIKELY TO EXCEED AN 8 -HR TWA
OF 5.0 MG /M3. A NIOSH APPROVED POSITIVE PRESSURE (SAR), FULL FACE RESPIRATOR
OR EQUIVALENT IS RECOMMENDED.
EYES (SPECIFY):
ANSI, CSA OR ASTM APPROVED SAFETY GLASSES WITH SIDE SHIELDS. TIGHT FITTING
DUST GOGGLES SHOULD BE WORN WHEN EXCESSIVE (VISIBLE) DUST CONDITIONS ARE
PRESENT. DO NOT WEAR CONTACT LENSES WITHOUT TIGHT FITTING GOGGLES WHEN
HANDLING THIS CHEMICAL.
FOOTWEAR (SPECIFY): RESISTANT TO CAUSTICS.
CLOTHING (SPECIFY):
FULLY COVERING SKIN. REMOVE WHEN WET OR CONTAMINATED. CHANGE DAILY.
OTHER (SPECIFY):
EVALUATE DEGREE OF EXPOSURE AND USE PPE IF NECESSARY. AFTER HANDLING LIME,
EMPLOYEES MUST SHOWER. IF EXPOSED DAILY, USE OIL, VASELINE, SILICONE BASE
CREME ETC. TO PROTECT EXPOSED SKIN, PARTICULARLY NECK, FACE AND WRISTS.
ENGINEERING CONTROLS (E.G. VENTILATION, ENCLOSED PROCESS, SPECIFY):
ENCLOSE DUST SOURCES; USE EXHAUST VENTILATION (DUST COLLECTOR) AT HANDLING
POINTS, KEEP LEVELS BELOW MAX. CONCENTRATION PERMITTED.
LEAK AND SPILL PROCEDURE:
LIMIT ACCESS TO TRAINED PERSONNEL. USE INDUSTRIAL VACUUMS FOR LARGE SPILLS.
VENTILATE AREA.
WASTE DISPOSAL:
TRANSPORT TO DISPOSAL AREA OR BURY. REVIEW FEDERAL, PROVINCIAL AND LOCAL
ENVIRONMENTAL REGULATIONS.
HANDLING PROCEDURES AND EQUIPMENT:
AVOID SKIN AND EYE CONTACT. MINIMIZE DUST GENERATION. WEAR PROTECTIVE
GOGGLES AND IN CASES OF INSUFFICIENT VENTILATION, USE NIOSH APPROVED DUST
RESPIRATOR. AN EYE WASH STATION AND SAFETY SHOWER SHOULD BE READILY
AVAILABLE WHERE THIS MATERIAL OR ITS WATER DISPERSIONS ARE USED. CONTACT
LENSES SHOULD NOT BE WORN WHEN WORKING WITH THIS CHEMICAL.
STORAGE REQUIREMENTS:
KEEP TIGHTLY CLOSED CONTAINERS IN A COOL, DRY AND WELL VENTILATED AREA, AWAY
FROM ACIDS. KEEP OUT OF REACH OF CHILDREN.
SPECIAL SHIPMENT INFORMATION:
QUICKLIME IS NEITHER REGULATED BY THE TRANSPORTATION OF DANGEROUS GOODS
(TDG) REGULATIONS (CANADA) NOR BY THE HAZARDOUS MATERIALS REGULATIONS (USA)
UNLESS THIS MATERIAL IS OFFERED OR INTENDED FOR TRANSPORTATION BY AIRCRAFT.
SECTION VIII - FIRST AID MEASURES
Page 6